7040 A 10L Integra E-Z User Manual 7-15-05

2y ago
12 Views
2 Downloads
293.96 KB
15 Pages
Last View : 2m ago
Last Download : 2m ago
Upload by : Julius Prosser
Transcription

Oxygen ConcentratorINTEGRA E-ZINSTRUCTION MANUALModel 6323A-OM-10Model 6323A-10P/N 7040 Rev AJuly 2005

Table of ContentsWarnings and Cautions . 3Indications for Use . 4Contraindications . 4Introduction. 4Important Safety Instructions. 4Symbols Used in Instruction Manual and on Oxygen Concentrator. 5Oxygen Concentrator Information . 6Using Oxygen Concentrators . 6Recommended Operating Environment Guidelines . 6The Proper Location. 7Before Operating Your Oxygen Concentrator . 7Operating Your Oxygen Concentrator . 8Installation Instructions. 9Select a Location. 9Inspect Inlet Air Filter. 9On/Off Button . 9Warm-up Period. 9Flow Rate Adjustment . 9Power Management Feature. 10Operating Conditions . 10Control Panel Display . 10Display of Operating Conditions . 11Usage. 11Non-Usage . 11Maintenance . 12Trouble Shooting Guide. 13Technical Data . 14Electromagnetic Compatibility . 15Disposal of Equipment and Accessories . 15SeQual Technologies Inc.2Part No: 7040

Warnings and CautionsWarning and Caution notices used in this manual apply to hazards or unsafe practices that could result in personalinjury or property damage.Federal law (U.S.A.) restricts this device to sale by or on the order of a physician."Read Instruction Manual" Do Not operate this oxygen concentrator without first reading andunderstanding this manual. If you are unable to understand the warnings and instructions, contactyour local SeQual dealer or authorized service representative before attempting to use thisoxygen concentrator."Caution or Attention” In certain circumstances, oxygen therapy can be hazardous, therefore, itis advisable to seek medical advice before using the oxygen concentrator.Do Not deviate from prescribed flow rates. Adjust the flow setting only to your prescribed flowrate, unless otherwise instructed by your physician.Warning: "No Smoking or Naked Flames" The use of oxygen therapy requires that specialcare be taken to reduce the risk of fire. Material that burns in air and even some material that willnot burn in air are easily ignited and burn rapidly in high concentrations of oxygen. For safetyconcerns, all possible sources of ignition must be kept away from the oxygen concentrator andpreferably out of the room in which it is being used. Smoking in the proximity of an operatingoxygen concentrator is dangerous, and can permanently damage the device and void the warranty."Use No Oil or Grease" A spontaneous and violent ignition may occur if oil, grease or otherpetroleum substances come into contact with oxygen under pressure. Keep these substancesaway from the oxygen concentrator, tubing and connections and any other oxygen source. DoNot use any petroleum based or other lubricants unless recommended by SeQual TechnologiesInc. Keep oxygen concentrator and cord away from hot surfaces. Do Not use the oxygen concentrator if it has adamaged cord or plug; contact qualified service personnel for examination and repair. Air intake of the oxygen concentrator should be located in a well-ventilated area. Oxygen concentrator should be located so as to avoid pollutants and fumes. If oxygen concentrator has been dropped, damaged or exposed to water, contact qualified service personnelfor examination or repair. Do Not drop or insert any object into any opening. Do Not block the air opening of the oxygen concentrator or place it on a soft surface, such as a bed or couch,where the bottom air opening may become blocked. Do Not cover unit with a blanket, towel, quilt, etc. Do Not place objects (pillow, blanket) under unit. Maintain at least ½ inch clearance under unit. Do Not overfill the humidifier, if used. Fill with distilled water only to the level shown by the manufacturer. Warning: Do Not remove the cover. Cover should only be removed by qualified service personnel. Warning: An alternate source of supplemental oxygen is recommended in the event of a power outage, alarmcondition, or mechanical failure.SeQual Technologies Inc.3Part No: 7040

Indications for UseThe SeQual Integra E-Z Oxygen Concentrator is intended to provide supplemental oxygen. It is not intended forlife supporting, or life sustaining applications nor does it provide any patient monitoring capabilities.ContraindicationsAn oxygen concentrator is not appropriate for any patient who would experience adverse health consequences asthe result of such temporary interruption.In certain circumstances oxygen therapy can be hazardous. It is advisable to seek medical advice before using thisoxygen concentrator.Warning: Federal law restricts this device to sale by or on the order of a physician.IntroductionYour physician has prescribed supplemental oxygen as part of a treatment plan. Long-term oxygen therapy isnow widely accepted as the standard treatment for chronic hypoxia caused by chronic obstructive pulmonarydisease. Oxygen therapy has become more versatile in recent years due to the development of oxygenconcentrators. The new devices make it easier for physicians to select a mode of oxygen therapy that suits thepatient's lifestyle.An oxygen concentrator has been prescribed to provide you with a source for supplemental oxygen. SeQual'sIntegra E-Z Oxygen Concentrator is an electronically operated oxygen concentrator that separates oxygen fromroom air. It does not remove oxygen from a room any more than by simply breathing the same room air. Youbreathe the added oxygen through nasal prongs of a cannula (small soft plastic tubes that fit just inside yournostrils).Your physician has prescribed a specific oxygen flow rate setting to meet your individual needs. This flow rate isdetermined by the amount of oxygen needed. Recommended oxygen flow rates should be adjusted onlyunder the advice of a physician.This oxygen concentrator is not intended for life supporting or life sustaining applications.As with any electrically powered device, the user may experience periods of non-operation as the result ofelectrical power interruption, or the need to have the oxygen concentrator serviced by a technician. Thisinstruction manual will inform you about the use and care of the Integra E-Z Oxygen Concentrator and will serveas a reference as you use your oxygen concentrator.Important Safety Instructions are shown under the following headings:Warning: Important safety information for hazards that might cause serious injury.Caution: Information for preventing damage to the oxygen concentrator.Do Not: Information to which you should pay special attention.Important: Clarifying information, specific instructions, commentary, sidelights, or interesting points.SeQual Technologies Inc.4Part No: 7040

Symbols Used in Instruction Manual and on Oxygen ConcentratorRefer to this section for an explanation of the symbols and the warnings that accompany them."Read Instructions" This symbol, when used alone or in conjunction with any of the followingsymbols, indicates the need to consult the operating instructions provided with the product. Apotential risk exists if the operating instructions are not followed."Attention or Caution" Consult accompanying documents This symbol indicates importantinformation that requires the user to take special precautions when certain conditions are present."No Smoking or Naked Flames" The use of oxygen therapy requires that special care be taken toreduce the risk of fire. Materials that burn in air and even some material that will not burn in airare easily ignited and burn rapidly in high concentrations of oxygen. For safety concerns, allpossible sources of ignition must be kept away from the oxygen concentrator and preferably out ofthe room in which it is being used. Smoking in the proximity of an operating oxygen concentratoris dangerous, and can permanently damage the device and void the warranty."Use No Oil or Grease" Indicates important information about the possibility of spontaneousand violent ignition that may occur if oil, grease or other petroleum based substances come intocontact with oxygen under pressure."Electrical Shock” Indicates the presence of an electric shock hazard. Warning: To reduce therisk of electric shock, do not remove cover. There are no user serviceable parts inside. Referservicing to a SeQual dealer or authorized service representative."Audible Alarm" An audible indicator is provided to announce, in a tone distinctly differentfrom the sounds generated by the oxygen concentrator during normal operation, a reduction inoxygen concentration, a large unintentional change in flow or when the mains power has beeninterrupted."Normal Operation" Green light is on indicating the concentrator is running under normaloperating conditions."ON/OFF" (condition) Push button starts concentrator running."Flow Rate Adjustment" The controll RedLightAudibleAlarmUnitStateOperating ConditionNoOffOffOffOffNotEnergizedUnit not running / FlowIndicator Display Not LitNoOffOffOffOffEnergizedUnit not running / FlowIndicator Display LitYesOnOnOnStartedRunningUnit is StartingYesOnOnOnRunningYesOnOnOffOn for OffRunningButton StuckYesOnOnOffOffRunning9V Battery Low Voltage(if enabled)Unit is warming up*RunningNormal OperatingConditionUnit turnedOn/Off/On QuicklyOxygen ConcentrationBelow Normal Level *O2 Flow Rate Not Correct10% off target flowOxygen ConcentrationAbnormal Level *1O2 Flow Rate Abnormal30% off target flow1Unit is overheatingNoOffOffFlashingOnNotRunningCompressor MalfunctionPower InterruptionInternal Fuse BlownNoOn orOffOn orOffOnOnRunningSystem Malfunction2* These conditions are displayed only on units equipped with oxygen monitor.1Call the Service Provider if abnormal conditions are detected and cannot be remedied.2During System Malfunction condition the Green and Yellow lights may be On or Off.3. Usage - Use recommended oxygen delivery accessories.Warning: Use of certain administration accessories not specified for use with this oxygenconcentrator may impair the performance.4. Non-Usage - When not using the oxygen concentrator, press the On/Off button to turn it off.SeQual Technologies Inc.11Part No: 7040

MaintenanceRoutine Maintenance: Routine maintenance consists of cleaning the air inlet filter at regular intervals to keep theunit functioning for years. The user can easily achieve this maintenance. When other than routine maintenance isneeded, contact your SeQual dealer/provider or authorized service representative.Warning: Unplug the oxygen concentrator from the power outlet before cleaning or routinemaintenance. Use a damp cloth for cleaning. Do Not directly apply liquid spray cleaners oraerosol cleaners. Cabinet and Power CordThe cabinet and power cord can be cleaned with a mild detergent solution applied with a damp cloth andtowel dried. Air Inlet FilterRoom air is drawn into the oxygen concentrator through the air inlet filter located on the top backside of thecabinet. Cleaning the air inlet filter is the most important activity you will perform to keep your oxygenconcentrator performing properly. Check this air filter daily and clean it at least once a week.1. Remove the filter from the cabinet.2. Wash the filter in warm water using a mild detergent solution.3. Rinse the filter thoroughly and squeeze out the excess water.4. Allow the filter to air dry.Caution: The filter should be free of liquid water and dry to the touch before reinstallation, asexcess moisture may impair the proper operation of the oxygen concentrator.5. Reinsert the filter in the cabinet.Caution: The air inlet filter should be replaced as needed. If the oxygen concentrator is used in adusty environment, the filter may need to be replaced more often. Do Not operate the oxygenconcentrator for more than 30 minutes without a filter installed. Oxygen Delivery Accessories - Follow the instructions supplied by the manufacturer.SeQual Technologies Inc.12Part No: 7040

Trouble Shooting GuideTable 1: Concentrator is not RunningSymptomCannot Start UnitFlow Indicator BlankBack Light OffAudible AlarmBlinking Red LightFlow Indicator BlankBack Light OffProbable CausePower cord not plugged into wall outlet. Plug in power cord.Internal Fuse BlownService required.Power cord pulled from wall outlet.Plug in power cord.Power outage.No power at wall outlet.Audible AlarmBlinking Red LightFlow Indicator BlankBack Light OnRemedyUnit overheatingCompressor malfunctionPush On/Off Button to turn offunit.Push On/Off Button to restart unitwhen power comes back on.Ensure the unit is not pluggedinto a wall switched outlet.Check house circuit breaker orfuse - reset or replace as needed.Remove any obstruction(s) fromair openings and refer to page 6“The Proper Location”.Service required.Table 2: Concentrator RunningSymptomProbable CauseRemedyNo oxygen / flowHumidifier or tubing blocked or kinkedClean or replace humidifierand/or tubing.Remove tube kink.(see Alarm Indications inTable on Page 11)Air Inlet Filter blockedClean air inlet filter.Internal component malfunctionService required.Restriction in humidifier or tubing.Repair or replace as required.Air Inlet Filter restrictedClean air inlet filter.Internal component worn ormalfunctioningService required.Button is stuckService required.LCD malfunctionService required.System malfunctionRemove power cord from walloutlet.Service required.Low oxygen / flow(see Alarm Indications inTable on Page 11)Yellow Light OnFlow Rate not visible onFlow Indicator DisplayAudible AlarmRed Light OnFlow Indicator BlankBack Light OnNote: If abnormal operating conditions are detected and cannot be remedied, contact your Service ProviderSeQual Technologies Inc.13Part No: 7040

Technical DataFlow RateOxygen ConcentrationOxygen Concentration IndicatorOxygen Outlet PressureElectrical PowerOperating TemperatureDimensions (H x W x D)Audible Alarm IndicatorsBack-up Alarm PowerFiltersDevice ClassificationTransport/Storage RequirementsBack pressure Effect onFlow IndicatorOSCI Operation*0.5 to 10.0 LPM1.0 to 10.0 LPM 91 3% at sea levelGreen Light Normal OperationYellow Light Flashing Below Normal Operation (85%*)Red Light Flashing Abnormal Operation (70%**)Nominal 6.0 psi (41.4 kPa) 1 - Maximum 11.0 psi (75.8 kPa)115V , 60Hz, 5.0A Nominal, 220-240V , 50Hz, 2.2A Nominal50 F to 104 F (10 C to 40 C)26.5 in. (66 cm) H 14.7in

An oxygen concentrator has been prescribed to provide you with a source for supplemental oxygen. SeQual's Integra E-Z Oxygen Concentrator is an electronically operated oxygen concentrator that separates oxygen from room air. It does not remove oxygen from a room any more than by simply breathing the same room air. You

Related Documents:

7030.70 Rules of evidence 7030.80 Briefs, arbitrators' decisions 7030.90 Opening/closing statements 7030.100 Voluntary arbitration PART 7040 REVIEW 31 7040.10 Perfecting a review 7040.20 Assignment of reviews 7040.30 Review hearing dates and places 7040.40 Conduct of review hearings 7040.50 Remanding orders

Integrated Oilfield Services from planning to production Integra Management LLC 119311, Russia, Moscow Prospect Vernadskogo, 6 Phone: 7 (495) 933 0621 Fax: 7 (495) 933 0622 reception@integra.ru www.integra.ru. Integra has been listed on the London Stock Exchange since 2007 (LSE: INTE)

Bellows-type detergent pumps 1 on-board 10L liquid detergent dispenser 1 on-board 10L liquid neutralizer dispenser 3optional off-board 10L dispensers Dispensing volume control system using ultrasound technology Modular basket system 1-3

product information disclosure integra lifesciences corporation (“integra”) has exercised reasonable care in the selection of materials and the manufacture of these products. integra warrants that these products shall conform to the product limited warranty as provided in the product labeling or

directed by the online or telephone service and support team. Damage due to servicing that is not authorized by Dell is not covered by your warranty. Read and follow the safety instructions that came with the product. . OptiPlex 7040 - Small Form Factor Owner's Manual Dell

d-7034 d-7035 d-7036 d-7037 d-7038 d-7039 d-7040 d-7041 d-7042 d-7043 d-7044 d-7045 d-7046 d-7047 d-7048 d-704

TYPES OF PACKAGES INCLUDE A. Website Sponsorship has many advantages including exposure on the Rotary District 7040 website. Most sponsorship packages include a logo with link to your website. Visitors to the District 7040 website are members and

Based on the results obtained, it can be concluded that learning by using guided inquiry-based chemistry module is effective in improving students' character and concept understanding. Keywords: T. he effectiveness of learning ,Character Guided Inquiry Module Concept Understanding Classical Completeness Criteria . 1. Introduction . Chemistry is one of the subjects that is closely related to .