INTERIOR / BODY - Mopar

3y ago
22 Views
2 Downloads
3.46 MB
28 Pages
Last View : 17d ago
Last Download : 2m ago
Upload by : Farrah Jaffe
Transcription

INTERIOR / BODY .11

MOPAR PERFORMANCE TERMS AND CONDITIONSNOTICEFederal and many state laws prohibit the removal, modification or rendering inoperativeof any part or element of design affecting emissions or safety on motor vehicles used fortransporting persons or property on a public street or highway. Violation may result in afine of up to 32,500 per vehicle. Mechanical and/or electronic performance parts listedin this catalog with a “1” cannot be used on vehicles used on public streets or highways.These parts may be used only on vehicles used solely in sanctioned off-highway events. No other applicationsare intended or implied. Those parts that have been granted an exemption by the California Air Resources Board(CARB) or meet the EPA requirements of memorandum 1A are legal for highway use in California, New York, andMassachusetts and are noted as such.NO PARTS WARRANTY – “AS IS”Mopar Performance parts beginning with a “P” prefix are sold “as is” unless otherwise noted. This means thatparts sold by Mopar Performance carry no warranty whatsoever. Implied warranties, such as warranties of merchantability, are excluded. (An implied warranty of merchantability means that the part is reasonably fit for thegeneral purpose for which it was sold). The entire risk as to quality and performance of such parts is with thebuyer. Should such parts prove defective following their purchase, the buyer and not the manufacturer, distributoror retailer, assumes the entire cost of all necessary servicing or repair. Chrysler, Jeep , Dodge and Ram vehicleand parts warranties are voided if the vehicle or parts are used for competition. The addition of performance partsdoes not by itself void a vehicle’s warranty. However, added performance parts (parts not originally supplied onthe vehicle from the factory) are not covered by the vehicle’s warranty, and any failure that they may cause is alsonot covered by the vehicle’s warranty.MOPAR PERFORMANCE CRATE ENGINE 90-DAY LIMITED WARRANTYMopar Performance Crate Engine Assemblies not used in competition are warranted for “parts only,” AS DELIVERED against defects in materials or workmanship for 90 days from the date of purchase. The following parts, ifdefective, will be replaced on an exchange basis for 90 days: engine blocks and all internal parts; cylinder headassemblies; intake manifold; core plugs; valve covers; oil pan; timing gear; water pump; gaskets and seals. Seeyour dealer for a copy of the limited warranty, which contains additional terms and limitations.MOPAR PARTS 12-MONTH LIMITED WARRANTYExcept parts as listed above, certain parts from Mopar Performance sold over the counter or wholesaled arewarranted against defects in workmanship or materials for 12 months/unlimited miles for parts (exchange) only.These parts are identified in this catalog as having a specific part number structure. Part numbers starting with“P” are not covered under the 12-month warranty. Other parts listed in this catalog without a “P” prefix part number are covered under the 12-Month Limited Warranty described here. See your dealer for a copy of the limitedwarranty, which contains additional terms and limitations. Parts installed on a Chrysler, Plymouth, Jeep , Dodgeand Ram vehicle by an authorized Chrysler, Jeep , Dodge and Ram dealer are warranted for 12 months/unlimitedmiles for parts (exchange) only. See your dealer for a copy of the limited warranty, which contains additional termsand limitations.

EMISSIONS STATEMENTFederal law requires emissions parts on new vehicles to be warranted for at least two years or 24,000 miles,whichever comes first. Federal and many state laws also prohibit the removal, modification or rendering inoperative any part that affects emissions or safety on motor vehicles used on public streets or highways. ManyMopar Performance parts are designated for track use or off-road use only. Installation of certain componentsmay bring the vehicle out of compliance with safety and/or emissions standards. Mopar recommends thatvehicles with parts designated in this fashion not be operated on public roads. Mopar Performance customersare responsible for complying with applicable state and local environmental regulations. Additionally, certainperformance parts may affect the emissions characteristics of the vehicle. If you install them on the vehicle,and your vehicle consequently fails a required state or local I/M (inspection and maintenance) emissionstest, including any test required to maintain or renew your vehicle’s registration, or if your vehicle is subjectto an emissions recall, Chrysler Group LLC may not be required to repair your vehicle under the emissionsperformance warranty, and you may be required to remove those parts at your own expense in order to obtainrepairs necessary to pass the I/M test or to perform the recall.NOTE — CALIFORNIA ONLYThe emissions laws and regulations of the state of California apply to all non-racing vehicles operated inCalifornia. Consequently, those parts marked in this catalog with a “1” and appropriately marked on theirpackaging may legally be used in California only on a racing vehicle that will never be operated on publicroads.PARTS ORDERING AND INQUIRIESThe parts in this catalog may be ordered from authorized Chrysler, Jeep , Dodge and Ram dealerships or thespeed shops carrying the Mopar Performance line of products. When a part ordered has been superseded,the replacing part will be shipped automatically. The price of the replacing part may differ from the orderedpart. All products, illustrations and specifications are based upon current information at the time of publicationapproval. Although descriptions are believed correct, complete accuracy cannot be guaranteed. ChryslerGroup LLC reserves the right to make changes at any time, without notice or obligation, to the informationcontained in this printed document, including and without limitation to prices, specifications, equipment,colors, materials, and to change or discontinue products.Select images in this catalog are used with permission of Mopar Nationals, Inc., Chrysler Historical Society, and the Walter P. Chrysler Museum.

TABLE OF CONTENTSENGINES . . . . . . . . . . . . . . . . . . . . . . . . . . . 10Hemi , Gen III . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10Crate Engines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Pistons and Connecting Rods . . . . . . . . . . . . . . . . . . . . . . .Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .Carburetors and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . .Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Transmission and Drivetrain . . . . . . . . . . . . . . . . . . . . . . . .Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .101011121212121314141515171719Hemi , Gen II . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22Crate Engines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Engine Installation Components . . . . . . . . . . . . . . . . . . . . .Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . .Pistons and Connecting Rods . . . . . . . . . . . . . . . . . . . . . . .Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22242525262627272829303234353739Big Block . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . .Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .424242434344505153P. 4Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .54565760Small Block . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .64Crate Engines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . .Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6466696970717478828587909395RESTORATION . . . . . . . . . . . . . . . . . . . . . . 100Fuel Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .100Carburetors and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .Fuel Pumps and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .Vapor Separator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Six Pack Induction Systems . . . . . . . . . . . . . . . . . . . . . . . . .Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Fuel Injection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .100101102102104106Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . .108Distributors and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . .Electronic Ignition Systems . . . . . . . . . . . . . . . . . . . . . . . . .Ballast Resistors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Ignition Wires and Spark Plugs . . . . . . . . . . . . . . . . . . . . . .Coils . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Starters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Voltage Regulators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . .Alternators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .108109110111112113113114114Automatic Transmission . . . . . . . . . . . . . . . . . . . . . . . . . .116Flex Plates and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . .Shifters and Shift Improvement Kits . . . . . . . . . . . . . . . . . . .Automatic Transmission Components . . . . . . . . . . . . . . . . .Transmission Overhaul Kits . . . . . . . . . . . . . . . . . . . . . . . . .Transmission Pans and Hardware . . . . . . . . . . . . . . . . . . . .116116116118119

TABLE OF CONTENTSTorque Converters and Hardware . . . . . . . . . . . . . . . . . . . .119Manual Transmission . . . . . . . . . . . . . . . . . . . . . . . . . . . .122Flywheels and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . .Bell Housing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Clutch Discs, Pressure Plates and Hardware . . . . . . . . . . .Shifters and Shift Improvement Kits . . . . . . . . . . . . . . . . . . .122123123125Drivetrain and Rear Axle Components . . . . . . . . . . . . . .128Universal Joint and Yoke Kits . . . . . . . . . . . . . . . . . . . . . . .Rear Axle Components . . . . . . . . . . . . . . . . . . . . . . . . . . . .Differential Components . . . . . . . . . . . . . . . . . . . . . . . . . . .128129130Steering, Suspension, and Brakes . . . . . . . . . . . . . . . . . .132Leaf Springs and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .Frame Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Torsion Bars and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .Suspension Seals and Bushings . . . . . . . . . . . . . . . . . . . . .Manual Steering Hardware . . . . . . . . . . . . . . . . . . . . . . . . .Shocks and Struts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .132135135135136136136Interior/Body . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .140Underhood . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Grilles and Headlamp Bezels . . . . . . . . . . . . . . . . . . . . . . . .Hoods and Hood Components . . . . . . . . . . . . . . . . . . . . . .Handles . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Trunk . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Racks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Bumpers/ Bumperettes . . . . . . . . . . . . . . . . . . . . . . . . . . . .Lamps and Lenses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Sheetmetal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Wheelhouse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Valence . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Emblems and Decals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Wheel Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . smission Components . . . . . . . . . . . . . . . . . . . . . . . . .Suspension Upgrades and Components . . . . . . . . . . . . . . .Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .GTS-R Engine Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Exterior Body Components . . . . . . . . . . . . . . . . . . . . . . . . .168169170171171173Eight-Cylinder Late Model Vehicles . . . . . . . . . . . . . . . . .176Electronic Control Modules . . . . . . . . . . . . . . . . . . . . . . . . .Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Exterior Body Components . . . . . . . . . . . . . . . . . . . . . . . . .Interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Suspension Upgrades and Components . . . . . . . . . . . . . . .Drivetrain and Rear Axle Components . . . . . . . . . . . . . . . .176176177179180180181Four- and Six-Cylinder Late Model Vehicles . . . . . . . . . .184Turbo Service Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .Engine Struts and Mounts . . . . . . . . . . . . . . . . . . . . . . . . . .Pistons and Connecting Rods . . . . . . . . . . . . . . . . . . . . . . .Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .Valve Train Hardware and Components . . . . . . . . . . . . . . .Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .Suspension Upgrades and Components . . . . . . . . . . . . . . .Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . .Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Transaxle Components . . . . . . . . . . . . . . . . . . . . . . . . . . . .Wheel Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Exterior Body Components . . . . . . . . . . . . . . . . . . . . . . . . .Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Bearing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98198198RACING . . . . . . . . . . . . . . . . . . . . . . . . . . . . 202CHRYSLER/DODGE . . . . . . . . . . . . . . . . . . 164Viper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .164Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Viper SRT10 Power Kit . . . . . . . . . . . . . . . . . . . . . . . . . . . .Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . .Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Differential Components . . . . . . . . . . . . . . . . . . . . . . . . . . .164164165165166167Drag Racing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .202LC22R Challenger Drag Pak Service Parts . . . . . . . . . . . . .Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Gear Drives and Service Parts . . . . . . . . . . . . . . . . . . . . . .Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .Hemi Pro Stock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Race Bodies . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .202203207207207208208208P. 5

TABLE OF CONTENTSSprint Car / Midget / Dirt Late Model . . . . . . . . . . . . . . . .212Blocks . . . . . . . . . . . . . . .

warranty, which contains additional terms and limitations. Parts installed on a Chrysler, Plymouth, Jeep , Dodge and Ram vehicle by an authorized Chrysler, Jeep , Dodge and Ram dealer are warranted for 12 months/unlimited miles for parts (exchange) only. See your dealer for a copy of the limited warranty, which contains additional terms

Related Documents:

PARTS & ACCESSORIES LIMITED WARRANTIES MOPAR BASIC LIMITED WARRANTY Subject to the terms and exclusions below, Mopar Parts and Magneti Marelli Parts offered by Mopar sold in Canada, on or after October 1, 2014 and installed by an authorized FCA Canada Inc. dealership or studio are warranted against defects in workmanship or materials for 24 months for both parts and labour. Mopar .

140 / diesel products / www.mopar.com the Mopar advantage Diesel engines anD parts cylinder head assembly — Mopar will still remanufacture the cylinder heads when a complete engine replacement isn't necessary. Mopar Diesel In-Line, 6-cylinder heads use original equipment components and meet strict original equipment engineering standards.

Canada are not covered by the Mopar Basic Limited Warranty. Mopar Parts, and Magneti Marelli Parts offered by Mopar sold in Canada, before October 1, 2014 are covered by the 12 month, unlimited kilometres warranty. There is no labour allowance for parts sold wholesale to an automotive facility.

Jeep et Mopar présentent 6 nouveaux concepts lors du 46e Easter Jeep Safari à Moab (Utah) Tous les concepts présentés sont équipés de Pièces et Accessoires Jeep Authentic, nouvelle division 4x4 de Mopar Jeep J-12 Concept : version allongée du kit JK-8 Mopar Jeep Wrangler Apache : nouveau moteur Mopar V8 Hemi 6.4 l

TRW/Thompson Power Steering Pump. 161010. 901323 REV B 05/30/19, PG 1 OF 7. This Kit Is Designed to Fit 1966-70 Mopar B-Body Vehicles . 1966-70 Mopar B-Body with TRW/Thompson Power Steering Pump Packing List: 1. NOTE: Images may not depict actual parts and quantities. Refer to packing list for actual parts and quantities.

BASIC LIMITED WARRANTY Except as noted below, Mopar Parts and Magneti Marelli Offered by Mopar parts installed by an authorized FCA US LLC dealership, including Chrysler, Dodge, Jeep , Ram, FIAT and Alfa Romeo locations are warranted against defects in workmanship or materials for 24 months/unlimited miles for both parts and labor.

Jeep, Mopar, Wrangler, the Jeep grille, Freedom Top, Master Shield, the Mopar Owner Connect design, Mopar Vehicle Protection, Rubicon, Sahara, . The appearance of accessories shown may vary depending on vehicle application. . authentic parts and accessories designed by the same engineers that

Chrysler, Dodge, Jeep, Ram, Mopar, Freedom Top, the Jeep grille, the Jeep Wrangler vehicle profile design, Mopar Vehicle Protection, Rubicon, Trail Rated, the Trail Rated 4x4 design and Uconnect are registered trademarks and Gladiator and Trail Rail . MOPAR AUTHENTIC ACCESSORIES JEEP .