LCT Parts Quick-Reference Guide

2y ago
21 Views
2 Downloads
1.17 MB
17 Pages
Last View : 1m ago
Last Download : 5m ago
Upload by : Annika Witter
Transcription

LCT Parts Quick-Reference GuideSummer Engine PartsWinter Engine Partspg. 2pg. 3Recoil Starters pg. 4-5Air Filter Elementspg. 61-Piece Ignitionspg. 9-102-Piece IgnitionsIgnition Test with LOSpg. 7-8pg. 11Ignition Wiring Pictures(1-pc/2-pc ignitions) pg. 12-13Charging Coils pg. 14-16

LCT SUMMER ENGINES136cc208cc291cc414cc1362400120824011 (paper AF)20824031 (Lg Poly AF)20824041 (Sm poly AF)20824051 (remote choke)291240014142400199001990019950199501Choke Lever/Knob20821201208212014142120141421201Breather Tube20845101208451014144510141445101Spark plug20838101208381012911550129115501Recoil Starter2083200220832001 ‐ Hex20832002‐Round2913200141432001Gasket kit13643001208430012914300141443001FOAM Filter Element2082011220820111 (Lg Poly AF)20820112 (Sm Poly AF)2912011141420111Foam d Paper Air Filter20820121208201214142012141420121Low Oil Sensor 5001414275014142750129125101(used on Serial Numbersgreater than1185H0927221)29125101(used on Serial Numbersgreater than11115H0927221)CarburetorCarb repair kitIgnition Coil(used on 2‐piece)CDI Black Box(used on 2‐piece)Ignition Coil ‐ NEWIntegrated (1‐piece)LOS Module (Gold Box)used with 1‐piece ignition &Low Oil Sensor SwitchOil Gauge PlugSmall Black Dipstick11/4/201320825001 (coil only)20825001 (coil only)20825003 (coil & CDI box) 20825003 (coil & CDI box)208275012082750120825701 (with shield)20825701 (with shield)20825201 (without shield) 20825201 (without shield)(SN greater than(SN greater 93012085930120837111208371114143711141437111Oil Plug otary On/Off Switch20826001208260012082600120826001Electric Starter (12V)N/A208805012918050141480501

LCT WINTER ENGINESItemCarburetorCarburetor w/ Idle ControlCarburetor Repair KitChoke Lever/ KnobFuel Control KnobSpeed Control KnobPrimer Bulb/Tube AssemblyBreather TubeSpark PlugRecoilGasket KitCrankcase Gasket KitIgnition CoilCDI BoxOil Gauge PlugOil Plug, Non‐removableOil Drain ExtensionOil Drain Plug w/washerRocker On/Off SwitchRotary On ‐ Off SwitchKey SwitchKeys120v Starter230v Starter3/25/2015136cc136cc208cc2‐Stage Single Stage GEN 00145031N/AN/AN/AN/AN/A03041030610304120845101 20845101 2084510120838101 20838101 2083810106002060020600113643001 13643001 208430017350173501735510417104171 2082500304041040410404120837111 20837111N/A20837051 20837051 2083705107001N/A0700120899111 20899111 4cc291cc414cc306cc369cc414ccGEN II Single Stage GEN IIGEN IIGEN IIGEN IIIGEN IIIGEN 23101 SEE GEN III 30414304120845101 20845101 20845101 41445101 41445101 41445101 41445101 4144510120838101 20838101 20838101 20838101 20838101 20838101 20838101 943001 4144300120843001 20843001 25443001 29143001 41443001 4404144041N/AN/AN/A20837111 20837111 20837111 41437111 41437111 41437111 41437111 4143711120837051 20837051 20837051 41437151 41437151 41437151 41437151 9111 20899111 20899111 41499111 41499111 41499111 41499111 412144121N/A4412144121

LCT ‐ 208cc RECOIL IDENTIFICATIONSUMMERPart #20832001Part #20832002WINTERPart #06001Part #06002

LCT ‐ 291cc RECOIL IDENTIFICATIONSUMMERWINTERPart #29132001Part #26001LCT ‐ 414cc RECOIL IDENTIFICATIONSUMMERPart #41432001WINTERPart #46001

LCT AIR CLEANER ELEMENTSPart #20820111Large "N" style Poly Element(208cc)Part #20820112Small "N" style Poly Element(136/208cc)Part #20820121Pleated Paper Elementincludes Foam Pre‐cleaner(136/208cc)Part #41420121Pleated Paperp Elementincludes Foam Pre‐cleaner(291/414cc)

2‐piece IgnitionsPart #208250032‐piece Ignition Kit for 208ccGEN I Snow & Summer EnginesLead Wire Length 7.75"Mounts with plug wire "UP"UPPart #20825001Ignition Coil Onlyfor 208cc 2‐piece IgitionsLead Wire Length 7.75"Mounts with plug wire "UP"Part #20827501CDI Box Onlyused on 208cc(ALL 2‐piece ignitions)Part #069012‐piece Ignition Kit for 208ccGEN II Snow EnginesLead Wire Length 10.5"Mounts with plug wire "DOWN"

2‐piece IgnitionsPart #41425001Ignition Coil Onlyused on 291/414cc Summer2‐piece ignitionsPart #41427501CDI Box Onlyyused on 291/414cc Summer2‐piece ignitionsPart #46901Ignition Coil Onlyused on 291/414cc Snow2‐piece ignitionsLead Wire Length 12.75"Mounts with plug wire "DOWN"DOWNPart #44041CDI Box Onlyused on 291/414cc Snow2‐piece ignitions

1‐Piece Integrated IgnitionsPart #20825701(left) with shieldPart #20825201(right) no shieldIntegrated Ignition Coilused on 136/208cc SummerLead Wire Length 7.75"Mounts with plug wire "UP"Part #29125101Integrated Ignition Coilused on 291/414cc SummerPart #04171Integrated Ignition Coilused on 136/208cc SnowStandard Lead WireLead Wire Length 1010.5"5"Mounts with plug wire "DOWN"Part #04161Integrated Ignition Coilused on 136/208cc SnowHi‐Temp (Blue) Lead WireLead Wire Length 10.5"Mounts with plug wire "DOWN"

1‐Piece Integrated IgnitionsPart #04181Integrated Ignition Coilused on HOP single‐stage208cc SnowPart #46921Integrated Ignition Coilused on 291/414cc SnowStandard Lead WireLead Wire Length 12.75"Mounts with plug wire "DOWN"Part #24031Integrated Ignition Coilused on 291/414cc SnowHi‐Temp (Blue) Lead WireLead Wire Length 12.75"Mounts with plug wire "DOWN"Part #20859301Isolator Module (Gold Box)used on SUMMER ONLY 1‐pieceignitions systems with LOSswitch

Part #20827001 (136/208cc)Part #41427001 (414cc)Low Oil Sensor Switch (LOS)gused on SUMMER ONLY engineswith LOS featureTest for NO‐START Ignition with LOS SwitchStep 1 ‐Check oil level to be full and ignition switch in "ON" position. Check for spark at sparkplug. Good Spark ‐ OK, No Spark problem with ignition system, go to step‐2Disconnect LOS Switch wire from LOS Isolator (Gold Box) yellow wire. Check continuityStep 2 ‐ from LOS Switch wire to engine block, there should be NO CONTINUITY. If continuity,replace LOS Switch per engne specification; if no continuity,continuity go to Step‐3.Step‐3Leave wires disconnected and recheck for spark. If good spark and engine starts, thenI l t (Gold(G ld Box)B ) iis defectived f ti ‐ replacelP t # 20859301.Part20859301SStep3 ‐ LOS IsolatorIf NO SPARK, replace ignition coil per engine specification.

2-Piece Ignition WiringLCT Ignition Wiring2-piece ignition with Low-Oil-Shutdown(LOS) switch installed. If thereis no LOS, then that wire is just tied-up and not used.Note: the service replacement CDI modual may not have a “yellow” wirelike the original, use the black wire with the same length to connect toLOS switch. The LONGEST black wire MUST connect to the ignitioncoil. The remaining Black Wire connects to on/off switch and Green wireis grounded to block.

1-Piece (Integrated) Ignition WiringLCT Ignition Wiring1-piece “integrated ignition” coil with LOS. If the engine does not haveLOS, then the “Isolator (Gold Box)” is also removed.The 1-piece itegrated ignition can replace a 2-piece ignition as described:- for engines with LOS, you must use the Gold Box as shown in this picture (part #20859301)- for engines with NO LOS, you can remove the Black Box and just connect on/off switch to NEW 1-piece coil ground wire

LCT Charging SystemsCPC# 07701HOP# 4249596‐watt ACused on ALL LCT modelsTest @ 3600 rpm no‐load, Voltage Output 36‐40V ACCPC# 07601HOP# 58115260118‐watt DC with 1‐wireused on 208cc HOP 2‐stage snowthrowersTest @ 3600 rpm no‐load, Voltage Output 12V DC, Current 1.5 AmpCPC# 07801HOP# 44409018‐watt DC with 2‐wiresused on 208cc HOP singel‐stagesnow throwersTest @ 3600 rpm no‐load, Voltage Output 12V DC, Current 1.5 Amp

LCT Charging SystemsCPC# 04141HOP# 443893Ariens# 2000103960‐watt AC with 2‐wiresused on 208cc Ariens/HOP 2‐stagesnow throwersTest @ 3600 rpm no‐load, Voltage Output 11‐14V ACCPC# 24021HOP# 443896Ariens# 2000111160‐watt ACused on 291/414ccg snow throwers2‐stageTest @ 3600 rpm no‐load, Voltage Output 11‐14V AC

LCT Charging SystemsCPC# 41417101HOP# 42924336‐watt AC / 27‐watt DC SplitSystemused on HOP 291/414cc SnowTest @ 3600 rpm no‐load, Voltage Output 12‐14V AC, Current 3 Amp; 12V DC, Current 2 Amp

Nov 04, 2013 · Ariens# 20001039 60‐watt AC with 2‐wires used on 208cc Ariens/HOP 2‐stage snow throwers Test @ 3600 rpm no‐load, Voltage Output 11‐14V AC CPC# 24021 HOP# 443896 Ariens# 20001111 60‐watt AC used on 291/414cc 2‐stage snow throwers Test @ 3600 rpm no‐load, Voltage Output 11‐14V AC

Related Documents:

and LCT. Our results demonstrate substantial genetic structure and differentiation between PCT and LCT populations. In contrast to current thinking, our phylogenetic reconstructions show the PCT to be a distinct evolutionary lineage that diverged from LCT before the LCT

show incipient albitization. In the Mesolcina valley, LCT and mixed LCT-NYF miarolitic pegmatites crosscut amphibolites and migmatitic gneiss. In the Codera valley LCT and NYF pegmatites are hosted by tonalites

official "pre-spring buying show," the largest event of its kind. The National Limousine Association is our official partner. Print and online advertisers receive special booth pricing AND premium placement on the show floor. In addition to the International LCT Show, LCT-NLA Show East and the LCT

International LCT Show LCT-NLA East LCT Leadership Summit Industry Summit School Bus eXchange Work Truck eXchange. page2 For more than 50 years, Bobit Business Media has built a reputation as a prominent business-to-busines

QUICK REFERENCE CATALOG 2008 QR QUICK REFERENCE SERVICE PARTS CATALOG 14.95 USD. T A B L E O F C O N T E N T S QUICK REFERENCE CATALOG TABLE OF CONTENTS SECTION 01 - SWITCHES . Set/resume 01969997 Multi-function gauge 01656487 High idle. QUICK REFERENCE CATALOG Switches 1-1

official "pre-spring buying show," the largest event of its kind. The National Limousine Association is our official partner. Print and online advertisers receive special booth pricing AND premium placement on the show floor. In addition to the International LCT Show, LCT-NL

Service Manual. PGH4516310/14/13 rev D. ENGINEERING A NEW GENERATION OF POWER. Table of Contents. Engine Model Number & Serial Numbering System 2-3 General Specifications 4-5 General Troubleshooting 6-7 Advanced Troubleshooting (for authorized LCT technicians) 8-10 Spark Plug Service 10 Engine Oil Level Check 11 Engine Oil Change 11 Engine .

Listening Ability (LS) The ability to understand speech DAS-II VERBAL COMPREHENSION 2:6-6:6 WJ III NU ACH ORAL COMPREHENSION 2-90 . KTEA II LISTENING COMPREHENSION 4:6 25-2 DETAILS 6 11 LCT-2 MAIN IDEA 6-11 LCT-2 UNDERSTANDING MESSAG