POOL FROG Mineral Pool Care System

2y ago
45 Views
2 Downloads
2.41 MB
18 Pages
Last View : 1m ago
Last Download : 2m ago
Upload by : Grant Gall
Transcription

POOL FROGMineral Pool Care System Model 5400/5430For Pools up to 40,000 Gallons BRANDCYCLER Adopt A FROG forWorry-Free Water!56 Less work with no daily dosing. Reduces chlorine use up to 50%.* Adopt an easier, more fun poolenvironment.814723*Compared to the minimum EPA recommended chlorine level of 1.0 ppm for a stabilized swimming pool.System Includes thePOOL FROG Mineral Reservoir Patented Mineral DisinfectantCustomer Service 800-222-0169www.KingTechnology.com1

TABLE OF CONTENTSPOOL FROG Introduction3Swimming Pool Tips4Start-up and Operation5-6Replacing POOL FROG Mineral Reservoir7Using FROG BAM 8Using POOL FROG Bac Pac9Troubleshooting10Parts List11Replacing Control Dial O-Rings12Replacing Cap O-Rings and Knobs12Winterizing13In-line Installation14Off-line Installation15-16For Proper Performance17Warranty18For information on King Technology’s entire productline, visit our website at www.KingTechnology.com2

POOLFROG Welcome to easier pool care courtesy of POOL FROG . With POOL FROG , yourpool water will look and feel better without a lot of work or a lot of chlorine.This system† controls bacteria using a combination of minerals and reducedchlorine levels–up to 50%* less. There are 4 parts to the POOL FROG System:The In Ground POOL FROG Cycler, the POOL FROG Mineral Reservoir, FROGBAM 90-day Algae Preventative and the POOL FROG Bac Pac.Part 2POOL FROG Mineral ReservoirPart 1POOL FROG CyclerThe water treatment center that controls the flow ofwater to each part of the POOL FROG System.Holds the minerals and fits inside the POOL FROG Cycler. BRANDFor In Ground Poolsup to 40,000 gallons.451Use with the POOLFROG System foran Algae-ProtectionGuarantee.8Part 3FROG BAM 6723L FROGTHE POO SERVOIRL REMINERACEDE REPLA SMUST BHIX MONTEVERY S NE POOLROOR AFTE HICHEVERWSEASON RTER.HIS S O CYCLERPart 4POOL FROG Bac Pac Pre-filled with chlorine tablets andfits inside the POOL FROG MineralReservoir.BRD(POOL FROG Mineral Reservoir sold inside POOL FROG Mineral Cycler and separately for replacements.POOL FROG Bac Pac and FROG BAM sold separately.)†FROG Mineral System consists of the FROG minerals silver chloride and carbonate used in conjunction with 0.5 ppm chlorine. The FROG Mineral Reservoir mustbe used in conjunction with the FROG Bac Pac (EPA Reg. No.: 53735-2), an EPA registered chlorine pool product or a chlorine delivery device.*Compared to the minimum EPA recommended chlorine level of 1.0 ppm for a stabilized swimming pool.3

Swimming Pool TipsStart-up and Yearly Maintenance1.3.Make sure the pool has adequate circulation. The poolwater must completely circulate through the pump andfilter at least 1 to 2 times per day. This usually requires8 to 12 hours. Check with your dealer for the propercirculation time for your pool.If your fill water is high in metals, use a sequesteringagent or metal out product at start-up only before usingthe POOL FROG Mineral Reservoir. See your local dealerfor details on using these products and always followmanufacturers directions carefully.4.2.After your pool is up andrunning smoothly, continue totest your water for pH, totalalkalinity and chlorine withFROG Brand Test Strips andmaintain its balance by addingany necessary adjustmentproducts (see your dealer fordetails).Before beginning with any pool care program, you mustfirst balance your pool water. Take a water sample to yourlocal pool professional or use a complete test kit that willtest for the following important elements.Water Balance GuidelinespH:Total Alkalinity:Calcium Hardness:Total Dissolved Solids:Stabilizer:Free Chlorine:47.2 – 7.860 – 120 ppm150 – 400 150020 – 80 ppm0.5 – 1.0 ppm5.Check the pool’s filter gaugeoften and periodically cleanfilter per the manufacturer’sdirections. A dirty filterwill slow the flow of waterwhich could hamper propercirculation.

Start-up and OperationRZEILIAB3TShock the pool with chlorine to ridthe water of all contaminants beforebeginning with POOL FROG . Followmanufacturer’s directions carefully.4.Replace cap and run POOLFROG Cycler, with POOLFROG Mineral Reservoirinserted, for 10 minutes onSetting MAXIMUM.5.For an Algae ProtectionGuarantee insert FROG BAM into POOL FROG MineralReservoir in POOL FROG Cycler. (Follow directions onpage 8.) 2.Add a stabilizer or conditioner to thepool at the beginning of the seasonif the stabilizer level is below 20ppm. This will prevent chlorine burnoff. Follow manufacturer’s directionscarefully."2 !. 1.THIS STEP IS VERY IMPORTANT TOSTART-UP. USE CHLORINE SHOCKONLY."2 !. 3.0//, &2/' "!# 0!#Do not add shock in or near the skimmer orinto the POOL FROG Cycler as it could damageequipment, risk potential explosion or discoloryour pool surface.6.When chlorine reading is downto 1.0 ppm, which may take afew days, insert POOL FROG Bac Pac. (Follow directions onpage 9.)Install a POOL FROG MineralReservoir into the POOL FROG Cycler.(Follow directions on page 7.)REPLACE THE POOL FROG MINERALRESERVOIR EVERY 6 MONTHSOR AFTER ONE POOL SEASONWHICHEVER IS SHORTER.PacRemovalMaximum5

Start-up and OperationThis system is designed to work effectively with a variety of pool equipment as long as the following basicprocedures are followed.control dial by matching up the parameters of your pool on the chart below. THIS IS A STARTING POINT ONLY and may7. Setneed to be adjusted to fit your individual pool needs. See #8 below for adjusting directions.IMPORTANT: Pump-run times of at least 6 hours per day at high speed are recommended for proper performance.If running the pump at low speed only or on high speed less than 6 hours, please follow the 24 hour low-speed directionsbelow.SINGLE-SPEED PUMP OR HIGH-SPEED PUMP RUN TIME6 HOUR PUMP RUN TIME12 HOUR PUMP RUN TIMEPUMP SIZEPUMP SIZEPOOL SIZEGallons3/4 hp1 hp1 1/2 hp2 hp3/4 hp1 hp1 1/2 hp24 HOUR PUMP RUN TIMEPUMP SIZE2 hp3/4 hp1 hp1 1/2 hp2 0NRNRNR7.0NRNR6.55.56.55.54.54.0* – Bypass installation recommended. NR – This pump size is not recommended for this size pool.6 HOUR PUMP RUN TIMEPOOL SIZEGallons24 HOUR, LOW-SPEED PUMP RUN TIMEIn order to ensure proper performance when running the pump on low speedfor 24 hours per day or high speed less than 6 hours per day, bleed the airwhile the pump is on by unscrewing the cap knob until water appears.Thenscrew the knob back on. Repeat this process each time the cap is removedfor any reason. Set the control dial at 6 and follow the adjustment directionsin Step 8 to determine the correct setting for your pool.PUMP SIZE3/4 hp1 hp1 1/2 hp2 05.035,000NRNR7.06.040,000NRNRNR7.0Find your starting dial setting by matching up theparameters of your pool on the above chart. An In groundpool with approximately 18,000 gallons with a 1 horsepower pump running 6 hours a day at high speed wouldrequire a starting dial setting of 5. Example above.the first week test the pool water daily8. Forfor free chlorine with FROG Brand Test Strips to ensure correct dial setting. Continueto test weekly throughout the season.If using another means of chlorine support, followsteps 1-5 on page 5 then continue below.After each testing, adjust the dialup by 1/2 increment if the freechlorine reading has droppedbelow 0.5 ppm or adjust down by1/2 increment if the reading hasrisen above 1.0 ppm. Continuethis process each day until the freechlorine reading stabilizes to at least 0.5 ppm.Remember to adjust dial by 1/2 increments only inorder to prevent over chlorination which may bleach poolsurfaces.9.Shock pool every two weeks or as needed tomaintain water quality. Follow label directionson the shock treatment used.Do not add shock in or near the skimmeror into the POOL FROG Cycler as it coulddamage equipment, risk potential explosionor discolor your pool surface.66.Set dial to Maximum. Maintain aminimum chlorine reading of 0.5ppm with a chlorine delivery deviceor hand feeding.7.Shock pool every two weeks or as neededto maintain water quality. Follow labeldirections on the shock treatment used.Do not add shock in or near theskimmer or into the POOL FROG Cycleras it could damage equipment, riskpotential explosion or discolor your poolsurface.

Replacing a POOL FROG Mineral Reservoir(POOL FROG Mineral Reservoirs MUST be Replaced Every Season)1.4.Turn off pump.Turn dial toPac Removal. This reducesthe flow of water into the unitwhen the cap is open.Check the top of the box and back label of product to makesure you have the correct POOL FROG Mineral Reservoir to fityour POOL FROG Cycler.THE POOL FROG MINERAL RESERVOIR MUST BEREPLACED EVERY 6 MONTHS OR AFTER ONE POOLSEASON WHICHEVER IS SHORTER2.IMPORTANT: Remove and read theinformation card.5.Please note: Complete instructionsfor inserting a POOL FROG MineralReservoir, FROG BAM and POOL FROG Bac Pac are included inside the POOLFROG Mineral Reservoir3.Use the cap tool includedwith POOL FROG Cycler toloosen cap by hitting thehandle with the flat of yourhand counter clockwise.Stand back to avoidinhaling chlorine fumesfrom the POOL FROG BacPac.6.USE ONLY the factory recommendedreplacement POOL FROG Mineral Reservoir,FROG BAM and POOL FROG Bac Pac.DO NOT USE bulk chemical tablets inthe POOL FROG Cycler or put anythinginside the POOL FROG Cycler, other thanthe appropriate POOL FROG product asdirected in the product instructions. Use ofany other product could result in damageto pool equipment or surface, unsafe poolconditions, fire or explosion. Warranty willbe void if the correct POOL FROG MineralReservoir, FROG BAM and POOL FROG BacPac are not used.Find slot on side ofPOOL FROG MineralReservoir and lineup with fin inside thePOOL FROG Cycler.Lower POOL FROG Mineral Reservoirinto POOL FROG Cycler until secure.7

Using FROG BAM for an Algae Protection GuaranteeIf you are not using FROG BAM , proceed to Step 15.See FROG BAM product labeling for complete directionsfor use (EPA Reg. No. 53735-9).For a preventive dose add: One FROG BAM for pools up to 15,000 gallons. Two FROG BAM for pools between 15,000 and 30,000 gallons.*NOTE: If using directly after a shock treatment, test the water first to ensure the pH is in the proper range of 7.2-7.8 and the chlorinelevel is no more than 4.0 ppm. Avoid using other chemicals until this product has been circulated (filtered) for at least 24 hours.11.7. Remove cap from FROG BAMwithout removing seal.Turn pump on for 90 minutesallowing FROG BAM tocirculate through pool.12.To remove FROG BAM , turnpump off. Turn dial to PacRemoval.8.Insert upside down intocenter of POOL FROG MineralReservoir pushing down firmlyon key to puncture seal.13.Remove POOL FROG Cyclercap.9.14.Replace cap by hand only.DO NOT OVER TIGHTEN.10.Turn control dial on POOLFROG Cycler to Maximum.Lift FROG BAM up and allowany water in the container todrain through the POOL FROG Cycler before discarding intrash.NOTE: If water shows morethan a hint of blue inside POOLFROG Cycler, replace the POOLFROG Cycler cap, turn dial toMaximum and run the pump forone minute.14a. If pool size requiresadditional FROG BAM , repeatsteps 7-14.14b. When water is clear inPOOL FROG Cycler, proceed toinserting POOL FROG Bac Pac.8

Using thePOOL FROG Bac Pac19. POOL FROG Bac Pacrecommended to assure upto 50% reduction in chlorineuse*. POOL FROG Bac Pacsold separately.(EPA Reg. No. 53735-2)ColoredCaps"2 !. 15.USE ONLY the factory recommended replacement POOL FROG Bac Pac. (See label.)DO NOT USE any other pac or bulk chemical tablets in the POOL FROG Cycler. Use of anyother product could result in over chlorination, bleached liners, unsafe pool conditions,fire or explosion. Warranty will be void if the correct pac is not used. "2!. 16.Line up the small leg of the POOLFROG Bac Pac with the smallopening in the POOL FROG MineralReservoir and the large leg withthe large opening. Lower POOLFROG Bac Pac into POOL FROG Mineral Reservoir until secure.*Compared to the minimumEPA recommended chlorinelevel of 1.0 ppm for astabilized swimming pool.Avoid sparks, open flame orsmoking when handling thePOOL FROG Bac Pac.20.Replace cap by hand only. DO NOTOVER TIGHTEN.17.DO NOT USE CAP TOOL TOTIGHTEN CAP. Use for removalonly. "2 !. To remove POOL FROG BacPac colored caps, grab onto the lip of one cap with apliers and pull up until capreleases. Repeat the processfor the other cap.21.18."2!. PACTOWERSThe chlorine pacs are madeof HDPE plastic. Non-refillablecontainer. Do not reuse or refillthis container. Offer for recycling ifavailable. Rinse thoroughly beforerecycling or discarding in trash.Turn POOL FROG Bac Pacover and shake slightly untilchlorine tablets fall intotower areas.PACTOWERSMark your calendar for the sixmonth replacement of the POOLFROG Mineral Reservoir, 90-dayreplacement of FROG BAM andapproximate replacement timesfor the POOL FROG Bac Pac. Oncewetted, the time-released mineralcoating of the POOL FROG MineralReservoir is effective up to 6 consecutive months or onepool season whichever is shorter. After that time, even ifyou hear the spent media inside, it is no longer effectiveand must be replaced.9

TroubleshootingFor more in-depth troubleshooting, go to www.kingtechnology.comProblem1.What do I doif the water lookscloudy?Remedy1. Make sure your filtrationsystem is working properly(i.e. clean filter, skimmer andpump basket).2. Make sure circulation timeis adequate – increase pumptime if not.3. Make sure the pool isproperly balanced (see page 4).5. Make sure pool has afree chlorine reading of0.5 to 1.0 ppm.4. Shock the water toeliminate build up of anyorganic matter.6. Check with your dealerfor more information.2.What do I doif the water turnscolor?1. Metals in the fill water mayhave been oxidized. Have thepool tested. Shock the pooland clean the filter until waterclarity returns.2. Algae may be trying toform – shock the pool,increase circulation time ifneeded and clean the filter.3. Check with your dealer formore information.3.What do I doif algae forms in oron my pool?1. Use a nonmetallic(polyquat) algaecide per thedirections on the bottle andbrush the sides of the pooloften.2. Clean the filter and shockthe pool with chlorine dailyuntil water clarity returns.Protection Guarantee usingFROG BAM . See producthang tag for guaranteedetails.1. If you are unable tomaintain 0.5 to 1.0 ppm, firstmake sure there are chlorinetablets in the tower areasof the POOL FROG Bac Pacand it is installed properly. Ifa correction was made, testthe water in 24 hours.until the proper reading isachieved.4.What do I doif I am underchlorinating withthe POOL FROG Bac Pac?2. If still low, turn the dial upone setting and test thewater again in 24 hours.Continue raising the settingby one increment each day5.10What do I doif I am overchlorinating withthe POOL FROG Bac Pac?1. If the chlorine reading isover 3.0 ppm, remove thePOOL FROG Bac Pac fromthe POOL FROG MineralReservoir and test the waterdaily until the reading is downto 1.0 ppm.2. Reinsert the POOL FROG Bac Pac, lower the dial onesetting and test the wateragain in 24 hours. If thereading has risen, lowerthe dial one setting again.3. If you are in an area of thecountry that struggles withalgae growth, see your dealerregarding a 90-day Algae3. Shock the pool if thereading has been lower than0.5 ppm for more than oneday.4. Make sure pump run timeis at least 6 hours on highspeed (40 gpm or higher) orif not, bleed the air from thecap knob (see page 17 fordirections).Continue this process untilproper reading is achieved.3. If over-chlorinating at thelowest possible setting,consider decreasing thecirculation time. Dependingon your pump size, you maybe circulating the water morethan is necessary.4. Contact your dealer tohave your back pressuretested. If over 8 psi considera larger eye-ball fitting in the4. Check with your dealer formore information.5. Contact your dealer to haveyour back pressure tested toensure it is at least 4 psi.6. Check for a suction sideleak by looking for air bubblesin your pump basket or atthe return jet. Contact dealerfor help in correcting thissituation.7. Contact King Technology’sCustomer Service Departmentat 800-222-0169.return jet.5. Check to see if thepressure relief valve is looseor missing and replace.It is a clear plastic pieceapproximately 1” longinstalled inside near the base.If loose or missing, it canprovide another avenue forwater to reach the chlorine.6. Contact King Technology’sCustomer Service Departmentat 800-222-0169.

8&9Parts List Models 5400 and 543012183SILICONELUBRICANT194 B R AN DCYCLER98761011125131413INCLUDED WITH THE POOL FROG Model 5400REF. # DESCRIPTIONQTY. INCLUDEDREPLACEMENT PARTS FOR POOL FROG Model 5400REF. # PART NUMBER DESCRIPTION1&2345, 6, 71&2245, 6, 9718&9101819Cap w/O-RingBodyPressure Relief ValveControl Dialwith O-Ring & Snap RingKnob with O-Ring2” Male AdapterCap/Control Dial ToolSilicone Lubricant11112211Cap w/O-RingCap O-RingPressure Relief ValveControl Dialwith O-Ring & Snap RingControl Dial O-Ring KitKnob with O-Ring2” Male AdapterCap/Control Dial ToolSilicone Lubricant OFF-LINE PARTS Included with Model 5430REF. # DESCRIPTIONQTY. INCLUDED11*1213141516172” x 1/2” Bushing90 ElbowSmall Clamp6’ PVC TubingScoop GasketVenturi ScoopScoop Clamp2241222 Off-line parts11 to 17 v TO v APART ONSTRAIGHT PIPE /54,%4!FTER FILTERANDHEATER IFHEATERINSTALLEDREPLACEMENT PARTS FOR OFF-LINE Model 5430REF. # PART NUMBERDESCRIPTION).,%4"ETWEENPUMPAND FILTER -770001-22-785001-22-779001-22-79102” x 1/2” Bushing90 ElbowSmall Clamp6’ PVC TubingScoop GasketVenturi ScoopScoop Clamp11

POOL FROG Cycler MaintenanceReplacing the Control Dial O-RingsReplacing Cap O-Ring1.1.Using a needle nose pliers,find the snap ring tail locatedat approximately the fiveo'clock position under thecontrol dial.2.Hold cap in front of youupside down with the o-ringgroove facing up. Place oneend of o-ring into cap grooveat the point closest to you.Hold o-ring down with thethumb and index finger ofone hand.Pull down and out of thegroove.2.3.Using a large screwdriver,loosen the control dial.Carefully pry the dial until itpulls out.4.OTHER COPY?SILICONELUBRICANTCOPYCOPYCOPYCOPY5.6.Take hold of the far end ofthe o-ring with the thumband index finger of the otherhand. Roll o-ring slightlyback towards you as youstretch the o-ring into theremainder of the capgroove. B R AN DCYCLERCarefully replace the rubbero-ring without stretching it.Apply silicone lubricant, thatcame with your POOLFROG Cycler, on o-ring.3.Push control dial completelyinto the housing and turn thedial to setting 2.Replacing KnobsInsert the non-lipped end ofsnap ring into the grooveopening beginning at the 5o'clock position and push itup so that it threads itselfaround the control dial.SILICONELUBRICANTBack of CyclerLubricate o-ring often withsilicone lubricant that camewith your POOL FROG Cycler. DO NOT USEpetroleum based lubricants.Replace knob in back or oncap of POOL FROG Cyclerby unscrewing old one andscrewing in new one.Top of cap7.12Using a small screwdriver orpointed tool to help guide it,make sure the snap ringstays in the groove as it isinserted.

Winterizing1.4.Turn pump off and turn dialto Pac Removal.2.5.Remove cap.If POOL FROG Bac Pac stillcontains chlorine, wrap inplastic bag and store in shedor cool well-ventilated locationaway from children, pets, cars,motorcycles or anything metalthat can rust, pit, etc. Makesure POOL FROG Bac Pac isaway from open flame.Remove the POOL FROG Mineral Reservoir and discardin trash. Even if you hear spentminer

For In Ground Pools up to 40,000 gallons. Part 3 FROG BAM Use with the POOL FROG System for an Algae-Protection Guarantee. Part 4 POOL FROG Bac Pac Pre-fi lled with chlorine tablets and fi ts inside the POOL FROG Mineral Reservoir. (POOL FROG Mineral Reservoir sold inside POOL FROG Mineral Cycler and separately for replacements. POOL .

Related Documents:

System: Two In Ground Cyclers, the POOL FROG Mineral Reservoir, FROG BAM 90-day Algae Preventative and the POOL FROG Pac. Part 1 & 2 POOL FROG XL PRO Cyclers The water treatment centers that control the flow of water through the POOL FROG Mineral Reservoir in one and the POOL FROG Pac in the other. THE POOL FROG MINERAL RESERVOIR .

For Above Ground Pools up to 25,000 gallons. Part 3 FROG BAM Use with the POOL FROG System for an Algae-Protection Guarantee. Part 4 POOL FROG Bac Pac Pre-filled with chlorine tablets and fits inside the POOL FROG Mineral Reservoir. POOL FROG Mineral Reservoir sold inside POOL FROG Mineral Cycler and separately for replacements.

Young Frog, Father Frog, Mother Frog, Large and Terrible Frog, Mole 1, and Mole 2. SETTING The play takes place in and around Toad’s house and Frog’s house. Frog and Toad Are Friends Spring A Swim The Letter Frog and Toad Together The Garden Cookies Frog and Toad

#15 Frog, Supplier Y 11. Frog Wear #15 Frog, Supplier Y 12. Frog Wear #10 Frog, Supplier Y 13. Frog Wear #15 Frogs, Supplier Z 14. Frog Wear . Conventional Point Design with AREMA Recommended Point Slope 1/8” Wheel Risers Flat Top Profile 5/8” Gage Corner Radiu

An origami frog made from 8X8 paper An origami frog made from 9 ¾ X9 ¾ paper Measuring tape Origami jumping frog recording paper Origami jumping frog graph Create a Fair Test 1) Start your frog with feet on the line (beginning of the tape measure). 2) Flip your frog f

I2 NWI Sox Fossey I4 Team PA Larcinese J2 NKY Bandits Premier J4 Team Ohio Gray K2 Indy Dreams Gold Lewis K4 Steel City Cyclones Cox L2 Motor City Madness Collins L4 WV Firestix Haynes 9:30 POOL 14UP POOL GAME 1 POOL 14UP POOL GAME 1 POOL 14UP POOL GAME 1 POOL 14UP POOL GAME 1 POOL 14UP POOL GAME 1 POOL 14UP POOL GAME 1 POOL 14UP POOL GAME 1 .

The Frog Mineral {System} {Technology} {Formula} reduces chlorine use up to 50%*. Simply use the Pool Frog Mineral Reservoir with at least 0.5 ppm of an EPA registered source of chlorine or a chlorine delivery device. Using the Pool Frog Mineral {System} {Technology} {Formula} with

Arduinos, Lego Mindstorms, Scratch, Python, Sketchup and much more. Pupils can work on their own projects or follow tutorials to build amazing computing creations! Computing Top-Up* Years 7-11 Tailored to both Computing enthusiasts and technophobes, Computing Top-Up provides a chance to reinforce learning done in lesson time and to explore exciting new avenues of technology. Debating Society .