Thule Roof Racks Installation Instructions

HULL-A-PORT 834PARTS INCLUDEDBECAMGFHNJIdescriptionpartKLpart numberqty.Ahull-a-port assembly /–2Btube pad /8535540285353022–285355134Cbase pad /Dbase /Emetal bracket /Fcarriage bolt M6 x 50 /9150650318Gcarriage bolt M6 x 65 /9150665318Hknob M6 low /75307838Istrap assembly /7532030052Jbuckle bumper /85355932Khook /85354652L1/4" rope /85354662Marm pad /85330194Nend cap /85374454WARNINGS / LIMITATIONS Load bars must be at least 24" (610mm) apart forsafe use. Always tie down bow and stern of boat to vehiclebumpers or tow hooks. Do not exceed weight limitation of racks or factoryinstalled bars. Compatible only with sea kayaks, white water kayaks,and other similar boats. Ensure load carrier or factory cross bars are properlyinstalled and tight to vehicle. Failure to follow above guidelines voids warranty. Maximum boat load should not exceed 75lbs. (34kg.).5015933 03

1PRE-ASSEMBLYFor Use On Vehicles With Factory RacksFor Use On Aftermarket Roof RacksOR Thule square, Aero load bar and Yakima round load bar. Look up your vehicle in the included Hardware Fit Guide. Loosely attach 65mm carriage bolts and knobs as shown. Identify the proper bolt length for your vehicle. Loosely attach carriage bolt and knobs as shown.5015933 03

2 Place carriers on bars in line with each other. Assemble remaining hardware as indicated in step 1.NOTE:3 Tighten all knobs firmly and evenly.CAUTION: Bars must be at least 24" (610 mm) apart for safe use.NOTE: To remove carrier loosen knobs and metal bracket.Outside of vehicle.34 R oute free end of strap, with logo side up, through the Buckle Bumper as shown. Pull Buckle Bumper over buckle toprotect boat and vehicle while strapping down boat.LOADING BOATAB24" mininum Route straps through carrier above upper tube pads. Adjust upper pads to fit boat.5015933 03 Load boat with cockpit facing towards you. Center boat on carriers fore & aft.

5SECURING BOATA Route straps around boat and secure load bar as shown.B M ake sure weight is evenly distributed front to rear. SlideBuckle Bumper off the buckle. Place strap through thebuckle as shown. Tighten strap and reposition BuckleBumper over buckle. E nsure straps do not go over cockpit cowling or other non-load bearing boat details beforecinching straps.6SECURING BOAT Slide buckle bumper up strap to expose strap buckle. Route straps as illustrated. Pull strap firmly to secure boat to carrier. Slide buckle bumper down over buckle. Tie off loose end of strap.5015933 03

7LOADING BOAT Be sure to tie down bow & stern of boat to vehicle bumpers or tow hooks.8BOW / STERN TIE DOWN Carefully attach hook to end of rope.9 Use attachment strap for better load clearance, if necessary. A ttach bottom hook to vehicle bumper or tow hook. Attach rope to boator attachment strap and tie a firm knot. Do not overtighten as this coulddeform boat.NOTE:WARNING:5015933 03 Attach strap to boat prior to loading in carrier.Inspect rope before each use. Do NOT use if damaged. Avoid sharp edges, pinch points, abrasive or hot surfaces.

2014 WATERSPORT CARRIER FIT GUIDERECOMMENDEDBOLT SIZE (mm)LOAD BARS5565 80 *THULEüüüüüüINNOLOAD BARüLOAD BARROUND BARWHISPBARüüVEHICLE MAKE, MODEL, AND YEARRECOMMENDEDBOLT SIZE (mm)5565 80 3üüüüüüDODGECaliber / SRT4 / SXTCaravan / Grand CaravanDurango / Durango SportJourneyNitroEdge / Edge SportEscapeEscape (Glass Roof)Expedition / Expedition ELExplorerExplorer SportExplorer Sport TracFlexFreestarTaurus WagonWindstarüüüüüüüüAcadiaDenaliDenali XLEnvoyJimmySafari Van (Cargo & Passenger)SuburbanTerrainTerrain DenaliYukon / Yukon XLYukon Denali / Yukon Denali OLETAstro Van (Cargo & 4'92-15'95-15'02-04'13-14'09-14'97-04GMCBMWCTS Sport Wagon 5DREscalade / Escalade ESVEscalade EXT PickupSRX (Except "Sport Models")65 80 *FORDAUDIEnclaveEncoreRanierRendezvousHHRSpark 5DRSuburban / Suburban Z71Tahoe / Tahoe Z71TrackerTraxTraverseVenturePacificaPT CruiserTown & CountryVoyager / Grand VoyagerüYAKIMAX655CHRYSLERSPORTRACKAllroadA4 (Avant) WagonA6 WagonQ5Q7S4 WagonRECOMMENDEDBOLT SIZE (mm)CHEVROLET (continued)AEROBLADE (ARB) BARSRAPID AERO (RB) BARSSTEEL (LB) BARS422 XSPORTER BARS500 XSPORTER PRO BARSPRO BARSMDXRDXTSX Sport WagonZDXVEHICLE MAKE, MODEL, AND YEARüüüüCrosstourCR-VElement / Element SCOdysseyPassportPilotRidgeline / Ridgeline �üüüüü

2014 WATERSPORT CARRIER FIT GUIDEVEHICLE MAKE, MODEL, AND YEARRECOMMENDEDBOLT SIZE (mm)5565 80 11-14ClubmanEndeavorMontero SportArmadaFrontier 4DR Crew üüAztekMontanaTorrentTrans ITSUBISHILAND ROVEREvoque 5DRLR2LR3LR4Range Rover / Range Rover donaSorentoSoulSportageCX-5CX-9MPVProtégé 5 WagonTributeMarinerMontereyMountaineerSable WagonVillagerJEEPCherokeeCommander (Standard Crossbars)Compass / RallyeGrand CherokeeLibertyPatriot65 80 MAZDAüüüüINFINITIEX 35EX 37FX 35FX 45FX 50QX4QX50QX56QX60QX70QX80RECOMMENDEDBOLT SIZE (mm)LINCOLN'05-10'09-10HYUNDAIElantra GT 5DREntourageSanta FeSanta Fe SportTucsonVEHICLE MAKE, MODEL, AND ATURNOutlookVue

2014 WATERSPORT CARRIER FIT GUIDEVEHICLE MAKE, MODEL, AND YEARRECOMMENDEDBOLT SIZE (mm)5565 80 *SUBARUBaja 4DRForesterImpreza 5DRImpreza WRX / WRX STI 4DRImpreza WRX / WRX STI 5DRLegacy WagonOutback SportOutback Sport / WRX / STI WagonOutback WagonTribecaXV aja 4DRForesterImpreza 5DRImpreza WRX / WRX STI 4DRImpreza WRX / WRX STI 5DRLegacy WagonOutback SportOutback Sport / WRX / STI WagonOutback WagonTribecaXV CrosstreküüüüüüüüüüSUZUKIGrand VitaraXL-7TOYOTA4RunnerFJ CruiserHighlanderLand CruiserMatrixRAV4SequoiaSiennaTacoma 4DR Quad CabVenzaüüüüüüüüüVOLVOV50V70V70 üüüüüü

Terrain Denali '12-14 ü: Yukon / Yukon XL '92-15: ü: Yukon Denali / Yukon Denali