How To Replace A Fuel Filter On Volkswagen Transporter T4
How to replace a fuel filter onVolkswagen Transporter T4VIDEO TUTORIALImportant!This replacement procedure can be used for:VW TRANSPORTER IV Box (70A, 70H, 7DA, 7DH) 2.5 TDI, VW TRANSPORTERIV Bus (70B, 70C, 7DB, 7DK, 70J, 70K, 7DC, 7DJ) 2.5 TDI, VW TRANSPORTER IVPlatform/Chassis (70E, 70L, 70M, 7DE, 7DL, 7D 2.5 TDIThe steps may slightly vary depending on the car design.WWW.AUTODOC.CO.UK1–14
REQUIRED TOOLS:Phillips screwdriverFlat ScrewdriverWWW.AUTODOC.CO.UKFender cover2–14
AUTODOC recommends:Ensure adequate ventilation of the workplace. Fuel vapors arepoisonous.All work should be done with the engine stopped.CARRY OUT REPLACEMENT IN THE FOLLOWING ORDER:1Open the bonnet.2Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.WWW.AUTODOC.CO.UK3–14
3Remove the battery cover.4Remove the retainers of the fasteners of the fuel filter tubes. Use a flat screwdriver.5Loosen the fastening clamps of the fuel filter pipes. Use a Phillips screwdriver. Use a flatscrewdriver.WWW.AUTODOC.CO.UK4–14
6Detach the tubes from the fuel filter.AUTODOC recommends:Be careful! Fuel may leak from the filter housing and hoses.7Remove the fuel filterWWW.AUTODOC.CO.UK5–14
8Install a new fuel filter.AUTODOC recommends:Make sure that the fuel filter is positioned correctly. Consider thefuel flow direction mark.During installation, take care to prevent dust and dirt from gettinginto the fuel filter housing.Take care to only use quality filters.WWW.AUTODOC.CO.UK6–14
9Attach the tubes to the fuel filter.10Tighten the fastening clamps of the fuel filter pipes. Use a Phillips screwdriver.11Install the retainers of the fasteners of the fuel filter tubes.WWW.AUTODOC.CO.UK7–14
12Install the battery cover.13Remove the fender protection cover.14Close the hood.WWW.AUTODOC.CO.UK8–14
15Run the engine for a few minutes. This is necessary in order to make sure that the componentoperates properly.16Shut off the engine.AUTODOC recommends:Before the start be sure to bleed the fuel system to prevent the airinleakage.To protect the environment from pollution, be sure to dispose of theused filters at special collection points.WWW.AUTODOC.CO.UK9–14
DID YOU FIND THESE INSTRUCTIONSHELPFUL?YESNOBECOME A MEMBER OF AUTODOC CLUB!WWW.AUTODOC.CO.UK10–14
AUTODOC — TOP QUALITY AND AFFORDABLE CARPARTS ONLINEAUTODOC MOBILE APP: GREAT DEALS AND CONVENIENTSHOPPINGA GREAT SELECTION OF SPARE PARTS FOR YOUR CARWWW.AUTODOC.CO.UK11–14
BUY SPARE PARTS FOR VOLKSWAGENFUEL FILTERS: A WIDE SELECTIONWWW.AUTODOC.CO.UK12–14
CHOOSE CAR PARTS FOR VOLKSWAGEN TRANSPORTER T4FUEL FILTERS FOR VOLKSWAGEN: BUY NOWWWW.AUTODOC.CO.UK13–14
FUEL FILTERS FOR VOLKSWAGEN TRANSPORTER T4: THE BESTDEALS & OFFERSDisclaimer:The document contains only general recommendations that may be useful for you when you perform repair or replacement work. AutoDoc shallnot be liable for any loss, injury, damage of property occurring in the repair or replacement process due to incorrect use or misinterpretation ofthe provided information.AutoDoc shall not be liable for any possible mistakes and uncertainties in this guide. The information provided is for information purposes onlyand cannot replace advice from specialists.AutoDoc shall not be liable for incorrect or hazardous usage of equipment, tools and car parts. AutoDoc strongly recommends to be carefuland observe the safety rules when performing repair or replacement works. Remember: usage of low quality auto parts does not guaranteeyou the appropriate level of road safety. Copyright 2018 – All the contents of this website, in particular texts, photographs and graphics, are protected by copyright. All rights,including reproduction, publication, editing and translation rights, are reserved by Autodoc GmbH.WWW.AUTODOC.CO.UK14–14
Volkswagen Transporter T4 VIDEO TUTORIAL This replacement procedure can be used for: VW TRANSPORTER IV Box (70A, 70H, 7DA, 7DH) 2.5 TDI, VW TRANSPORTER IV Bus (70B, 70C, 7DB, 7DK, 70J, 70K, 7DC, 7DJ) 2.5 TDI, VW TRANSPORTER IV Platform/Chassis (70E, 70L, 70M, 7DE, 7DL, 7D 2.5 TDI The steps may slightly vary depending on the car design.
Fuel transfer pump (35) is mounted on the back of unit injector hydraulic pump (1). The fuel transfer pump pushes pressurized fuel out of the outlet port and the fuel transfer pump draws new fuel into the inlet port. Fuel is drawn from fuel tank (12) and flows through two micron fuel filter (11) . Fuel flows from fuel filter (11) to the inlet .
Oct 08, 1998 · replace snipers with hackers, replace bullets with data packets, replace chemical warfare with computer viruses, replace anti aircraft guns with firewalls, replace sentries with intrusion detection systems, replace military intelligence with auditing tools, replace physical battlefields with cyber equivalents that p o-
5-6 FUEL SYSTEM AND THROTTLE BODY FUEL TANK LIFT-UP Remove the front seat. ( 7-4) Remove the fuel tank mounting bolts. Lift and support the fuel tank with its prop stay. FUEL TANK REMOVAL Lift and support the fuel tank with its prop stay. (L7above) Disconnect the fuel pump lead wire coupler 10. Pla
Fuel Pressure: Fuel Pressure Regulator and System Pressure. Fuel System: Pumps, Relays . significant volume of fuel may come out. Be ready to catch all the gas in the filter . The 3 main things to check in the fuel circuit are the fuel pump relay, and the 2 fuel pumps. 1. Fuel Injection Relay Test
ATJ/F-24 fuel blend appears to result in accelerated wear in fuel-lubricated rotary fuel injection pumps. At various fuel inlet temperatures, the use of maximum concentration CI/LI in a 30% ATJ/F-24 fuel blend appears to retard the accelerated wear observed in prior fuel -lubricated rotary fuel injection pump studies.
fuel pressure to the fuel injection pump. The pressure regulator regulates the fuel at an absolute pressure of 150 kPa (22 psi) when the engine is at idle speed. The fuel injection pump increases the fuel to a maximum pressure of 200 MPa (2900 psi). The fuel injection pump delivers the fuel to the high-pressure manifold (Rail). The fuel .
The main difference between Carburetor and Fuel injection system {CarburetorzFuel is atomized by processes relying on the air speed greater than fuel speed at the fuel nozzle, zThe amount of fuel drawn into the engine depends upon the air velocity in the venturi {Fuel Injection SystemzThe fuel speed at the point of delivery is greater than the air speed to atomize the fuel.File Size: 2MB
the fuel pressure regulator, not the pump itself, to control pressure in the fuel rail. Any fuel not required by engine demand is diverted back to the fuel tank via the pressure regulator. Therefore, it’s impor-tant to remember that fuel pumps them-selves only supply fuel volume; they do not create pressure in the fuel lines.
