PARTS LIST FOR WCL-30D-0M10
PARTS LIST FORWCL-30D-0M10(Serial Break #30000296)WATER TREATMENT SYSTEM Copyright 2001, Mi-T-M Corporation1EX-9169-122106
Congratulations on the purchase of your new Mi-T-M Water Treatment System! This parts listing has been complied for your benefit. You can be assured yourMi-T-M Water Treatment System was constructed and designed with quality and performance in mind. Each component has been rigorously tested to insure thehighest level of acceptance.The contents of this parts listing are based on the latest product information available at the time of publication. Mi-T-M reserves the right to make changes inprice, color, materials, equipment, specifications or models at any time without notice.WARNINGTHIS IS A PROFESSIONAL WATER TREATMENT SYSTEM. CAUTION SHOULD BE OBSERVED WHEN USING OR REPAIRINGTHIS UNIT! READ AND FOLLOW THE SAFETY WARNINGS LISTED BELOW BEFORE ATTEMPTING ANY REPAIRS ONTHIS WATER TREATMENT SYSTEM!SAFETY WARNINGS1.Serious injury or death could occur if the water treatment system is not properly grounded. Your water treatment system is powered byelectricity and may cause electric shock or electrocution if not installed properly. Installation to this unit, including all electrical connections, must complywith all local, state and national codes. Any electrical wiring or repairs performed on this water treatment system should be done by AuthorizedServicePersonnel in accordance with National and Local electrical codes.2.NEVER alter or modify the equipment. Use only genuine Mi-T-M parts for repair of your water treatment system. Failure to do so can causehazardous operating conditions and will VOID warranty.3.Know how to stop and bleed pressures quickly. Be thoroughly familiar with controls. Do not operate without protective cover/guards. Follow themaintenance instructions specified in your operator's manual.4.Before servicing, ALWAYS shut off the water and the unit. Allow the unit to cool down and drain the water. NEVER assume the water recycling treatmentsystem is safe to work on just because it is not operating. It could restart at any time! ALWAYS disconnect from the power source. Service in a clean, dry,flat area.5.Be especially careful to properly dispose of any flammable materials. Consult Materials Safety Data Sheets for safe handling of chemicals used with yoursystem, especially oxidizers and acids. Copyright 2001, Mi-T-M Corporation2EX-9169-122106
Table of ContentsMAIN ASSEMBLY (BEFORE SERIAL #30000296).4MAIN ASSEMBLY (AFTER SERIAL #30000296).6CONE ASSEMBLY (BEFORE SERIAL #30000296).8CONE ASSEMBLY (AFTER SERIAL #30000296).9LID ASSEMBLY.10NOTES.11TANK ASSEMBLY (BEFORE SERIAL #30000296).12MAIN TANK DRAIN ASSEMBLY.14TANK ASSEMBLY (AFTER SERIAL #30000296).16TANK STAND ASSEMBLY (BEFORE SERIAL #30000296).18TANK STAND ASSEMBLY (AFTER SERIAL #330000296).20PLUMBING: OZONE ASSEMBLIES (BEFORE SERIAL #30000296).22OZONE INLET PLUMBING (AFTER SERIAL #30000296).24OZONE OUTLET PLUMBING (AFTER SERIAL #30000296).25OZONE PUMP ASSEMBLY (AFTER SERIAL #30000296).26OZONE PUMP (3-0199).27OZONE GENERATOR (32-0531) (BEFORE SERIAL #30000296).28OZONE GENERATOR ASSEMBLY (32-0861) (AFTER SERIAL #30000296).29PLUMBING ASSEMBLIES (BEFORE SERIAL #30000296).30OUTLET RING (AFTER SERIAL #30000296).32INLET PLUMBING (AFTER SERIAL #30000296).33OUTLET PLUMBING (AFTER SERIAL #30000296).34OIL SKIMMER OUTLET (AFTER SERIAL #30000296).35DECANTER TANK ASSEMBLY (855-0014).36SLUDGE BOX ASSEMBLY (855-0017).37SUMP PUMP (3-0180) (BEFORE SERIAL #30000296).38PUMP STRAINER BASKET (AFTER SERIAL #30000296).40CONTROL PANEL (BEFORE SERIAL #30000296).42CONTROL BOX ASSEMBLY (AFTER SERIAL #30000296).44LADDER DIAGRAM 24V AND 230V.46WIRE DIAGRAM.47PRODUCT TANK (80 GALLON) ASSEMBLY (855-0015).48PRODUCT TANK (165 GALLON) ASSEMBLY (855-0016).49 Copyright 2001, Mi-T-M Corporation3EX-9169-122106
WCL-30D-0M10-032700-WKBMAIN ASSEMBLY (BEFORE SERIAL #30000296) Copyright 2001, Mi-T-M Corporation4EX-9169-122106
WC L -3 0 D -0 M1 0 -0 3 2 7 0 0 -WK BMAIN AS S E MB LYREF. # D E S C R IP T IONPART#QTY.1Plumbing: Ozone Pump Inlet (See pg. 14)N/A Sep.12P lumb i ng : Outle t Te e (S e e p g . 1 8 )N/A Sep.13Ta nk A s s e mb ly (S e e p g . 1 0 )N/A Sep.14S lud g e B o x A s s e mb ly855-001715L i d A s s e mb ly (S e e p g . 9 )N/A Sep.16P lumb i ng : Outle t Ri ng (S e e p g . 1 8 )N/A Sep.17C o ne A s s e mb ly (S e e p g . 8 )N/A Sep.18P lumb i ng : Ozo ne P ump Outle t (S e e p g . 1 4 )N/A Sep19Plumbing: Oil Skimmer Outlet (See pg. 18)N/A Sep110Tank Stand Assembly (See pg. 12)N/A Sep111Oil Decanter Assembly855-0014112P lumb i ng : Inle t (S e e p g . 1 8 )N/A Sep113Sump Pump3-0180114F lo a t32-05281 Copyright 2001, Mi-T-M Corporation5EX-9169-122106
WCL-30D-0M10-120806-PJHMAIN ASSEMBLY (AFTER SERIAL #30000296) Copyright 2001, Mi-T-M Corporation6EX-9169-122106
WC L -3 0 D -0 M1 0 -11 0 7 0 6 -P J HMAIN AS S E MB LYREF. # D E S C R IP T IONPART#QTY.1Lid AssemblyN/A Sep.12Ta nk A s s e mb lyN/A Sep.13Ozo ne Outle t P lumb i ngN/A Sep.14Oi l S k i mme r Outle tN/A Sep.15Ta nk Sta nd A s s e mb lyN/A Sep.16D ra i n A s s e mb ly -WC L -3 0 D -0 M1 0N/A Sep.17S lud g e B o x A s s e mb ly855-001718D e c a nte r Ta nk A s s e mb lyN/A Se.p19Outlet PlumbingN/A Sep.110Ozone Generator Assembly -WCL-30D-0M10N/A Sep.111Inlet PlumbingN/A Sep.112Ozo ne Inle t P lumb i ngN/A Sep.113Float32-0528114Pump-Strainer Basket3-0214115Outlet Ring AssemblyN/A Sep.116Cone AssemblyN/A Sep.1 Copyright 2001, Mi-T-M Corporation7EX-9169-122106
CONE ASSEMBLY (BEFORE SERIAL #30000296)WCL-0002-030300-WKBCONE ASSEMBLYWCL-0002-030300-WKBREF. #DESCRIPTIONPART #QTY.1Screw27-304842Tee55-180113Pipe *(Varied Feet Required)55-180014Cone- Small33-033415Cone- Large33-033196Cone- Large w/ Lip33-029717Union (Includes O-ring 25-0448)55-164528Pipe *(Varied Feet bow23-0386112Check Valve55-08531*Must Order in One Foot Lengths Copyright 2001, Mi-T-M Corporation8EX-9169-122106
CONE ASSEMBLY (AFTER SERIAL #30000296)CONE ASSEMBLY -WCL-30D-0M10 110606-PJHCONE ASSEMBLYCONE ASSEMBLY-WCL-30D-0M10 110606-PJHREF. #DESCRIPTIONPART #QTY.1Adapter55-162222Pipe *(One Foot Required)55-160033Union55-164524Pipe *(Two Feet Required)55-160015Elbow23-038616Ball Check 01110Pipe *(Two Feet Required)55-1600111Pipe *(Three Feet Required)55-1600112Pipe *(One Foot Required)55-18001213Screw27-0348414Coalescing Cone33-0297115Coalescing Cone33-0331916Cone-Plain33-0334117Pipe *(One Foot Required)55-1800118Tee55-1801119Plug39-012032*Must Order in One Foot Lengths Copyright 2001, Mi-T-M Corporation9EX-9169-122106
LID ASSEMBLYLID ASSEMBLY-WCL-30D-0M10-PJHLID ASSEMBLY-WCL-30D-0M10-PJHLID ASSEMBLYREF. #DESCRIPTION1Lid2PART 6435Bolt27-89626 Copyright 2001, Mi-T-M Corporation10EX-9169-122106
NOTES Copyright 2001, Mi-T-M Corporation11EX-9169-122106
WCL-0009-032200-WKBTANK ASSEMBLY (BEFORE SERIAL #30000296) Copyright 2001, Mi-T-M Corporation12EX-9169-122106
WCL-0009-032200-WKBTANK ASSEMBLYREF. #DESCRIPTIONPART #QTY.REF. #DESCRIPTIONPART #QTY.1O-ring25-0447219O-ring25-044942Union (Includes O-ring 25-0447)55-1245220Union (Includes O-ring 25-0449)55-184543Pipe *(Varied Feet Required)55-1200121Pipe *(Varied Feet Required)55-180014Decal- Black and Yellow r55-182236Nipple55-1274224Tank Adapter (Includes Gasket 25-0481)55-188637Tank Adapter (Includes Gasket -0338128Ball ion (Includes O-ring 25-0448)55-1645330Adapter55-0054113Pipe *(Varied Feet ucer55-1832115Nipple55-1674133Nipple23-0012116Tank Adapter (Includes Gasket ank w/Lid (600 Gallons)12-0102118Adapter55-16222*Must Order in One Foot Lengths Copyright 2001, Mi-T-M Corporation13EX-9169-122106
MAIN TANK DRAIN ASSEMBLY-WCL-30D-0M10-PJHMAIN TANK DRAIN ASSEMBLY Copyright 2001, Mi-T-M Corporation14EX-9169-122106
MAIN TANK DRAIN ASSEMBLY-WCL-30D-0M10 120806-PJHMAIN TANK DRAIN ASSEMBLYREF. #DESCRIPTIONPART #QTY.1Adapter55-182212Pipe *(One Foot le23-001216Ball Valve22-027817Ball Valve55-185518Adapter55-182119Pipe *(One Foot Required)55-1200110Cam and Groove55-00541*Must Order in One Foot Lengths Copyright 2001, Mi-T-M Corporation15EX-9169-122106
TANK ASSEMBLY-WCL-30D-0M10 120806-PJHTANK ASSEMBLY (AFTER SERIAL #30000296) Copyright 2001, Mi-T-M Corporation16EX-9169-122106
TANK ASSEMBLY-WCL-30D-0M10 120806-PJHTANK ASSEMBLYREF. #DESCRIPTIONPART #QTY.1Decal-Mi-T-M Stripe34-072512Clarifier Tank12-006913Bulkhead Fitting (Includes O-Ring 25-0482)55-128634Bulkhead Fitting (Includes O-Ring 25-0481)55-168625Bulkhead Fitting (Includes O-Ring 33-033819Pipe *(One Foot Required)55-1200110Adapter55-12221 Copyright 2001, Mi-T-M Corporation17EX-9169-122106
WCL-0019-032200-WKBTANK STAND ASSEMBLY (BEFORE SERIAL #30000296) Copyright 2001, Mi-T-M Corporation18EX-9169-122106
WCL-0019-032200-WKBTANK STAND ASSEMBLYREF. #DESCRIPTIONPART #QTY.REF. #DESCRIPTIONPART Detergent Hose *(Nine Feet Required)15-002113Locknut30-5158519Check Valve22-028614Ozone Pump Assembly (See Exploded Drawing)N/A Sep.120Ball Valve22-007415Bolt27-5018721Cord *(Four Feet Required)32-007416Pipe Clamp42-0026422Wire Splice32-035937Nut30-52021323Strain Relief32-043718Tank Stand Base20-0512A01124Locknut32-010819Tank Stand20-0553A01125Ozone Generator32-0531110Bracket20-0555A01126Lid (See 32-0531)N/A Sep.111Locknut30-0163827Screw (See 32-0531)N/A Sep.812Washer28-00061628Control Box Assembly (See Exploded Drawing)N/A Sep.113Bolt27-0217829Bolt27-5016614Pipe Clamp42-0038330Washer28-0121615Control Panel Plate20-0523A01116Lockwasher29-10074*Must Order in One Foot Lengths Copyright 2001, Mi-T-M Corporation19EX-9169-122106
TANK STAND ASSEMBLY WCL-30D-0M10 110606-PJHTANK STAND ASSEMBLY (AFTER SERIAL #330000296) Copyright 2001, Mi-T-M Corporation20EX-9169-122106
TANK STAND ASSEMBLY-WCL-30D-0M10 110606-PJHTANK STAND ASSEMBLYREF. #DESCRIPTIONPART #QTY.REF. #DESCRIPTIONPART #QTY.20-0553A01113Decal- Warning Risk of Electorcution34-088411Tank Stand2Bolt27-5018614Control Box Assembly (See Exploded Drawing)N/A Sep.13Pipe sher28-012145Nut30-52021017Decal- Clear Laminate Serial34-021016Locknut30-5158218Decal- Data PlateN/A17Washer28-0122819Decal- Mi-T-M Spec's34-088518Bolt27-5066220Tank Leg Stand20-059649Pipe ontrol Panel Plate20-0523124Ozone Pump Assembly (See Exploded Drawing)N/A Sep.1*Must Order in One Foot Lengths Copyright 2001, Mi-T-M Corporation21EX-9169-122106
WCL-0014-0327-WKBPLUMBING: OZONE ASSEMBLIES (BEFORE SERIAL #30000296) Copyright 2001, Mi-T-M Corporation22EX-9169-122106
WCL-0014-032700-WKBPLUMBING: OZONE ASSEMBLIESREF. #DESCRIPTIONPART #QTY.REF. #DESCRIPTIONPART #QTY.1Plumbing: Ozone Pump Inlet (Inc. 2-6)N/A Sep.115O-ring25-044722Union (Includes O-ring 25-0447)55-1245316Adapter55-122213Pipe *(Varied Feet Locknut30-515845Ball Valve55-1255119Washer28-012286Decal- Black and Yellow Arrow34-0883320Pump Mount er55-1221222Plumbing: Ozone Pump (Inc. 2, 3, 11, 12, 14-21, 23-26)N/A Sep.19Injector55-0015123Terminal Flag32-0492210Check Valve55-1252124Terminal Fork32-0003111Elbow55-1210225Strain bing: Ozone Pump Outlet (Inc. 2-4, 6-12)N/A Sep.114Ozone Pump3-01991*Must Order in One Foot Lengths Copyright 2001, Mi-T-M Corporation23EX-9169-122106
OZONE INLET PLUMBING (AFTER SERIAL #30000296)OZONE INLET PLUMBING-WCL-30D-0M10 110606-PJHOZONE INLET PLUMBINGOZONE INLET PLUMBING WCL-30D-0M10 110606-PJHREF. #DESCRIPTIONPART #1Adapter55-122212Pipe *(One Foot l- Arrow34-088316Pipe *(Five Feet Required)55-120017Ball Valve55-125518Pipe *(One Foot educer Bush55-14331 Copyright 2001, Mi-T-M Corporation24QTY.EX-9169-122106
OZONE OUTLET PLUMBING (AFTER SERIAL #30000296)OZONE OUTLET PLUMBING-WCL-30D-0M10 110606-PJHOZONE OUTLET PLUMBINGREF. #DESCRIPTIONPART #QTY.REF. #DESCRIPTIONPART #QTY.1Adapter55-1222111Check Valve22-028612Pipe *(One Foot Coupler55-081514Pipe *(One Foot Required)55-1200314Pipe *(Two Feet Required)55-120015Union55-1245115Pipe *(Four Feet Required)55-120016Adapter55-1221216Decal- Arrow34-088317Mazzei Injector55-0015117Pipe *(Five Feet Required)55-120018Hose *(Four Feet Required)15-0226318Ball Valve55-125219Hose Barb22-0074119Elbow55-1210210Hose *(One Foot Required)15-0226220Nipple55-12741OZONE OUTLET PLUMBING-WCL-30D-0M10 110606-PJH*Must Order In One Foot Length Copyright 2001, Mi-T-M Corporation25EX-9169-122106
OZONE PUMP ASSEMBLY (AFTER SERIAL #30000296)OZONE PUMP ASSEMBLY-WCL-30D-0M10 110606-PJHOZONE PUMP ASSEMBLYREF. 012244Mount Plate20-0522A0115Cord *(Six Feet Required)32-007416Strain ONE PUMP ASSEMBLY-WCL-30D-0M10 110606-PJH1PART # Copyright 2001, Mi-T-M Corporation26EX-9169-122106
OZONE PUMP (3-0199)3-0199-061099-JTRRECIRCULATING PUMP (3-0199)3-0199-OZONE-061099-JTRREF. #DESCRIPTIONPART#QTY.27-01174N/A11Bolt2Motor- 1/2 H.P.3Seal Plate26-023714Square Ring25-047915Mechanical Seal26-021516Impeller46-085317Wear Ring46-083518Pump HeadN/A19Drain Plug39-0109110Motor Pad33-0320111Motor Pad Base5-01441Complete Recirculating Pump (Inc. 1-11)3-0199 Copyright 2001, Mi-T-M Corporation27EX-9169-122106
OZONE GENERATOR (32-0531) (BEFORE SERIAL #30000296)32-0531-032200-WKBOZONE GENERATOR (32-0531)32-0531-032200-WKBREF. #DESCRIPTIONPART#QTY.1Control ain Relief32-043719Cord *(Eleven Feet Required)32-0074110Hose *(Seven Feet Required)15-0021111Check 37114ScrewN/A815Control CoverN/A116ScrewN/A217Transformer Control32-0636118Hold-DownN/A219Cable Tie33-00222*Must Order in One Foot Lengths Copyright 2001, Mi-T-M Corporation28EX-9169-122106
OZONE GENERATOR ASSEMBLY (32-0861) (AFTER SERIAL #30000296)OZONE GENERATOR ASSY-WCL-30D-0M10 120806-PJHOZONE GENERATOR (32-0861)OZONE GENERATOR ASSEMBLY-WCL-30D-0M10REF. #DESCRIPTIONPART#QTY.1Screw27-503222Ozone Generator32-086113Decal- Air Inlet/Ozone Outlet34-163314Decal- Warning Inhal
Mi-T-M Water Treatment System was constructed and designed with quality and performance in mind. Each component has been rigorously tested to insure the . 10 Ozone Generator Assembly -WCL-30D-0M10 N/A Sep. 1 11 Inlet Plumbing N/A Sep. 1 12 Ozone Inlet Plumbing N/A Sep. 1 13 Float 32-0528 1 14 Pump-Strainer Basket 3-0214 1
Mi-T-M WCL-30D SERIES Operator's Manual 3 Congratulations on the purchase of your new Mi-T-M water treatment system! you can be assured your Mi-T-M water treatment system was constructed and designed with quality and performance in mind. Each component has been rigorously tested to ensure the highest level of acceptance.
Bruksanvisning för bilstereo . Bruksanvisning for bilstereo . Instrukcja obsługi samochodowego odtwarzacza stereo . Operating Instructions for Car Stereo . 610-104 . SV . Bruksanvisning i original
30D MS Standard Mast Limited Freelift 2-Stage For PIDs 30D-MS-001 Through Present P ARTS MANUAL FOR PARTS AND SERVICE: TELEPHONE: (888) 946-3330. PRODUCT I.D. NUMBER XXX-XX-XXX EXAMPLE MA2380.eps XXX-XX-XXXX About This Manual Introduction LIFT-TEK / ELECAR CUSTOMER SERVICE 7040 S. HWY. 11
30D-MT HCHAIN-1 OCL - Outer Chain Length OCL Qty 2. 235427 R6 10/05/10 page 15 Free Lift Hose 3 MA2340.eps See Chart FLHOSE-1 For 30D-MT-001 Through Present OAL FREE LIFT HOSE REF #3 (in) QTY #3 57 200176 60 200093 63 200096 69 200137 70 200138 73 200168 74 200169 79 200180 80 200181 81 200182 84 200136 86 683566 89 683569 92 683572 94 683574
FortiGate Rugged 30D FortiGate Rugged 35D FortiGate Rugged 60D FortiGate Rugged 90D Product SKU Description FortiGate Rugged 30D FGR-30D Ruggedized, 4x GE RJ45 ports, 2x GE SFP slots, 2x DB9 Serial. Maximum managed FortiAPs (Total / Tunnel) 2 / 2. FortiGate Rugged 35D FGR-35D Ruggedized,
FortiGate Rugged 30D FortiGate Rugged 35D FortiGate Rugged 60D FortiGate Rugged 90D Product SKU Description FortiGate Rugged 30D FGR-30D Ruggedized, 4x GE RJ45 ports, 2x GE SFP slots, 2x DB9 Serial. Maximum managed FortiAPs (Total / Tunnel) 2 / 2. FortiGate Rugged 35D FGR-35D Ruggedized, IP67 rating for outdoor environment, 3x GE RJ45 Switch ports.
10 tips och tricks för att lyckas med ert sap-projekt 20 SAPSANYTT 2/2015 De flesta projektledare känner säkert till Cobb’s paradox. Martin Cobb verkade som CIO för sekretariatet för Treasury Board of Canada 1995 då han ställde frågan
Creating an economy that harnesses artificial intelligence (AI) and big data is one of the great opportunities of our age. This Sector Deal is the first commitment from government and industry to realise this technology’s potential, outlining a package of up to 0.95bn of support for the sector, which includes government, industry and academic contributions up to 603m in newly allocated .
